STARCRAFT BUS Pdf Download PDF Report


Starcraft Bus, a Division of Forest River Inc. submitted a model Allstar-25, gasoline-powered 17 seat (including the driver) 25-foot bus, for a 7 yr/200,000 mile STURAA test. The odometer reading at the time of delivery was 529.0 miles.  Testing started on December 6, 2005 and was completed on February 14, 2006.  The Check-In section of the report provides a description of the bus and specifies its major components. 

The primary part of the test program is the Structural Durability Test, which also provides the information for the Maintainability and Reliability results.  The Structural Durability Test was started on December 14, 2005 and was completed on February 1, 2006.

The interior of the bus is configured with seating for 17 passengers including the driver + 1 wheelchair position.  Free floor space will accommodate 10 standing passengers resulting in a potential capacity of 27 persons + 1 wheelchair position.  At 150 lbs per person 600 lbs per wheelchair position, this load results in a measured gross vehicle weight of 13,950 lbs.  The first segment of the Structural Durability Test was performed with the bus loaded to a GVW of 13,950 lbs.  The middle segment was performed at a seated load weight of 12,500 lbs and the final segment was performed at a curb weight of 9,510 lbs. Durability driving resulted in no unscheduled maintenance and failures.

Accessibility, in general, was adequate, components covered in Section 1.3 (Repair and/or Replacement of Selected Subsystems) along with all other components encountered during testing, were found to be readily accessible and no restrictions were noted.

The Reliability section compiles failures that occurred during Structural Durability Testing. Breakdowns are classified according to subsystems.  The data in this section are arranged so that those subsystems with more frequent problems are apparent.  The problems are also listed by class as defined in Section 2.  The test bus encountered no failures during the Structural Durability Test.

The Safety Test, (a double-lane change, obstacle avoidance test) was safely performed in both right-hand and left-hand directions up to a maximum test speed of 45 mph. The performance of the bus is illustrated by a speed vs. time plot.  Acceleration and gradeability test data are provided in Section 4, Performance.  The average time to obtain 50 mph was 13.75 seconds.

The Shakedown Test produced a maximum final loaded deflection of 0.224 inches with a permanent set ranging between -0.003 to 0.005 inches under a distributed static load of 10,725 lbs. The Distortion Test was completed with all subsystems, doors and escape mechanisms operating properly. Water leakage observed during the test at the top of the rear door between the door and the door frame.  

The test bus was not equipped with any type of tow eyes or tow hooks, therefore, the Static Towing Test was not performed.  The Dynamic Towing Test was performed by means of a front-lift tow. The towing interface was accomplished using a hydraulic under-lift wrecker. The bus was towed without incident and no damage resulted from the test. The manufacturer does not recommend towing the bus from the rear; therefore, a rear test was not performed.  The Jacking and Hoisting Tests were also performed without incident. The bus was found to be stable on the jack stands, and the minimum jacking clearance observed with a tire deflated was 8.8 inches.

A Fuel Economy Test was run on simulated central business district, arterial, and commuter courses. The results were 6.39 mpg, 6.90 mpg, and 10.17 mpg respectively; with an overall average of 7.32 mpg.

           A series of Interior and Exterior Noise Tests was performed. These data are listed in Section 7.1 and 7.2 respectively.


Number: 0518
Model: ALLSTAR 25
Manufacturer: STARCRAFT BUS
Vin Number: 1FDXE45516HA98012