T80208 (CNG)

TRANSPORTATION MANUFACTURING CORPORATION (TMC) Pdf Download PDF Report

Unscheduled Maintenance

Date Test Miles Service Activity Downtime Hours
05-11-93 13880 Air conditioning not functioning. Loose plug repaired. 1.0 1.0
03-04-93 2162 Driver's window, top, and top right of windshield leaking water. Monitor for further leakage. 0.0 0.0
03-27-93 5539 Driver's window leaking water at top between window and frame. Monitor for further leakage. 0.0 0.0
04-01-93 6413 Console support mount below driver's window broken. Mount repaired. 0.5 0.5
04-08-93 7859 Left rear body panel cracked approximately 2." Monitor for further cracking. 0.0 0.0
04-23-93 9530 Water leaking in at the top of driver's window/frame. Inside, side driver's console, panel removed to inspect for water damage. None noted. 0.5 0.5
04-26-93 10445 Water leaking in at the top of driver's window/frame. Monitor for further leaking. 0.0 0.0
04-29-93 11238 Third seat, right side, is missing 2 rivets. Company rep. replaced 2 rivets. 0.25 0.25
05-05-93 12434 Driver's window leaking water. Monitor for further leakage. 0.0 0.0
05-05-93 12434 Fourth seat from the rear, on the right side, missing 10 rivets. Rivets replaced. 0.25 0.25
05-05-93 12434 Modesty panel behind driver's seat missing rivets. Rivets replaced. 0.25 0.25
05-26-93 15000 Destination sign latch is broken. Latch repaired. 0.25 0.25
03-27-93 5276 Horn sounding on its own. Loose wire in horn button repaired. 0.5 0.5
04-16-93 8646 Speedometer, volt gauge and water temperature gauge not functioning. Speedometer circuit breaker reset, wire repaired to speedometer, volt gauge and temperature gauge. (All three wires were chafed). 4.0 4.0
04-23-93 9588 Front marker light burned out. Lamp replaced. 0.25 0.25
04-28-93 10965 Water temperature gauge not functioning. Loose wire repaired. 0.25 0.25
05-17-93 14257 24 volt line in the electrical compartment chaffed. 24 volt line repaired. 18.0 5.0
03-01-93 1384 Bus transmission would not shift into gear. Rep. determined the idle was too high. Rep. adjusted idle at woodward box. 1.5 1.5
03-09-93 2331 Bus has a continuous loss of power. Company rep. and Cummins rep. trouble shooting. Cummins rep. replaced woodward box. 48.0 6.5
04-08-93 7859 CNG fuel filter inspected. Filter dirty. Fuel filter replaced. 0.25 0.25
04-08-93 7859 While verifying set-up of transmission for the fuel economy test, the company and ZF rep. found not throttle position sensor on the transmission. 04-09-03 sensor arrifed and installed. Transmission set-up verified. 25.0 2.0
05-13-93 13880 Engine: loss of power. No throttle. Cummins rep. adjusted governor control, reeplaced broken #6 spark plug boot. 24.0 4.0
03-26-93 5120 Exhaust pipe clamp fell off. Clamp repositioned and tightened. 1.0 1.0
04-15-93 8405 Hard exhaust pipe off of turbo outlet pipe flange is broken. Hard exhaust pipe off of the turbo replaced. 1.0 1.0
04-28-93 10965 Exhaust pipe clamp at turbo outlet is loose. Clamp tightened. 0.25 0.25
05-13-93 13880 Exhaust pipe off of turbo outlet. Pipe is cracked. Exhaust pipe replaced. 1.0 1.0
04-28-93 10965 Inspected CNG fuel filter. Dirty. Filter replaced. 0.25 0.25
05-05-93 12434 CNG fuel filter inspected. Filter dirty. Filter replaced. 0.25 0.25
05-11-93 13880 CNG fuel leak detected under the bus at the #10 cng fuel tank relief valve. #10 cng fuel tank relief valve leaking. All tanks shut off. All lines tightened and all relief valves tightened. 4.0 4.0
02-24-93 263 Wheelchair lift not functioning. Manufacturer notified testing center that the wheelchair lift was not adequately fastened at factory. Lift requires additional parts to become operational. 0.0 0.0
04-08-93 7859 Parts arrived for wheelchair lift. Ground sensing strip replaced, and fuse replaced. 2.5 2.5
04-08-93 7859 Bolt loose on parking brake. Bolts retorqued. 0.5 0.5
04-28-93 10965 Wheelchair lift not functioning. Company rep trouble shooting, found defective module. Module replaced. 3.0 3.0
05-14-93 14155 Wheelchair lift hydraulic line leaking. Hydraulic line replaced. 2.5 2.5
03-22-93 3993 Front sway bar links hitting lateral bars. Bar and links retorqued. 1.0 1.0
04-07-93 7806 Front left sway bar link broken. Left sway bar link replaced. 10.5 1.5
04-08-93 7859 Rep requested that all shocks be replaced. All shocks replaced. 1.5 1.5
04-12-93 8139 Front sway bar broken on the right side, left sway bar link (pin) sheared and right sway bar link bent. Front sway bar, and left andright sway bar l inks replaced. 55.25 3.5
04-23-93 9588 Company rep requested all shocks be replaced. All four shocks replaced. 2.0 2.0
04-28-93 10965 Rear leveling valve arm bolt is loose. Bus not at proper ride height. Bolt tightened and ride height adjusted. 0.25 0.25
04-29-93 11238 Rear ride height improper. Rear ride height adjusted. 0.5 0.5
05-03-93 11829 Bus not riding at proper height. Company rep. adjusted right rear leveling valve to correct ride height. 0.25 0.25
05-05-93 12434 Company rep. requests all shocks be replaced. All shocks replaced. 1.5 1.5
05-05-93 12434 Bolt missing fromsway bar saddle clamp. Bolt replaced. 0.25 0.25
05-18-93 14463 Sway bar, left side, saddle clamp has a broken bolt. Bolt replaced. 0.25 0.25
02-17-93 50 Drivers comment that bus steers hard. Steering system checked. No corrective action advised by manufacturer's representative. 0.5 0.5
02-18-93 125 Bus still steering hard. Steering system checked. No corrective action advised by manufacturer's representative. 0.5 0.5
02-19-93 193 Bus steering hard. Hydraulic pressures checked. 16.0 6.0
02-23-93 193 New steering gear received. Manufacturer's rep. installed new steering gear. 106.0 2.0
02-25-93 429 Bus does not steer as far to the left as it does to the right. Rep. adjusted steering linkage. 1.5 1.5
03-02-93 1598 Bus still steering hard. Rep. replaced steering actuator. 1.0 1.0