ER3116TAZ15

THOMAS BUILT Pdf Download PDF Report

Unscheduled Maintenance

Date Test Miles Service Activity Downtime Hours
06-24-93 1059 A/C condenser bracket is broken. Bracket removed and welded/repaired. 16.0 2.0
06-27-93 1505 Five screws missing and remaining loose on A/C unit cover. Screws replaced and tightened on A/C cover. 0.5 0.5
07-08-93 3275 Rear A/C unit will not run. Circuit breaker tripped. Circuit breaker will not reset. New breaker ordered. 1.0 1.0
07-18-93 5535 Ten fasteners missing from A/C cover. Ten fasteners replaced. 0.25 0.25
07-26-93 6867 Front A/C unit broke away from the wall brackets. Twelve stainless steel rivets replaced. 3.0 3.0
08-02-93 8169 Front A/C unit broken loose from mounting brackets. Rivets replaced to secure A/C unit. 1.0 1.0
08-05-93 8618 Front A/C unit broken loose from mounting brackets. Co. Rep. installed a new evaporator using carriage bolts through the roof bows. 6.0 6.0
06-18-93 284 Battery tie downs loose. Shifting of batteries caused on to crack. Tie downs re-secured and battery ordered. 2.0 2.0
06-20-93 630 Battery leakage from cracked battery reported on 6/18/93. Battery compartment cleaned and cracked battery topped off. 0.25 0.25
06-21-93 694 Tray in wheelchair lift compartment is loose. New nuts and bolts installed in tray and latch assembly. 1.0 1.0
06-22-93 962 Splash guard in front of oil pan is broken and hanging. Splash guard removed. 0.25 0.25
07-01-93 2044 Engine compartment interlock not functioning properly. Manufacturer recommends removal of interlock. Interlock removed. 0.25 0.25
07-08-93 3275 Right side, exterior rear view mirror loose. Mirror tightened. 0.25 0.25
07-08-93 3275 Hydraulic control for the wheelchair lift is missing the mounting fasteners. Fasteners replaced. 0.25 0.25
07-15-93 4772 Right side exterior rear view mirror; shaft is broken. Shaft welded/repaired. 1.5 1.5
07-15-93 4825 Two mounting screws on the right exterior rear view mirror are broken. Two screws replaced. 0.25 0.25
07-15-93 4825 Three screws missing from the exterior trim, top rear right cover. Three screws replaced. 0.25 0.25
07-15-93 4825 Rivet missing from the right, lower body panel, right of the radiator. Rivet replaced. 0.25 0.25
07-22-93 5996 Right side exterior rear view mirror fell off. Mirror replaced. 0.5 0.5
07-28-93 7332 Three screws missing from destination sign above driver's seat. Three screws replaced. 0.5 0.5
07-28-93 7332 Several screws missing from destination sign above driver's seat. Screws replaced. 0.25 0.25
07-30-93 7774 Right side exterior rear view mirror is missing two fasteners. Fasteners replaced. 0.5 0.5
08-04-93 8618 Handrail by rear door is missing various fasteners. Fasteners replaced. 0.25 0.25
08-11-93 8991 Right side exterior rear view mirror fell off. New mirror ordered. 0.0 0.0
08-12-93 9299 Rear view mirror reported on 8/11/93. Temporary repair until new morror arrives. 0.5 0.5
08-12-93 9375 Driver's side windshield cracked. Numerous cracks originating at the left center. Running in various directions across windshield. Manufacturer recommends no repair at this time. 0.0 0.0
08-18-93 10183 Outside windshield posts top and bottom are cracking. No repair recommended at this time. 0.0 0.0
08-18-93 10221 Body panel to the rear of the front door is loose. Panel positioned and four fasteners replaced. 1.0 1.0
08-18-93 10221 Chrome trim rear of bus both sides are loose. Chrome trim replaced with new fasteners. 0.5 0.5
08-24-93 11250 Left front windshield cracked 8/12/93 new windshield arrived. Left front windshield replaced. 1.5 1.5
08-24-93 11250 Engine compartment electrical panel mounting bracket is broken. Bracket welded/repaired. 2.0 2.0
08-24-93 11250 Fifth seat, left side, seat back is loose. Fasteners tightened. 0.25 0.25
08-24-93 11250 First seat, left side, wall mount stripped out. Bolt replaced. 0.25 0.25
08-24-93 11250 Welds are broken on the bottom of the battery compartment. Manufacturer recommends no repair due to completion of durability testing. 0.0 0.0
06-22-93 962 Air line to rear brakes is laying over the H-frame. Air line repositioned and fastened to eliminate potential chaffing. 0.25 0.25
06-29-93 1764 Air line to rear brakes rubbed through. Air line from valve to brakes replaced. 14.0 2.25
06-20-93 630 Bus shutting down. Found wire off of engine pressure switch. Wire replaced on pressure switch. 0.25 0.25
06-21-93 694 Battery ordered on 6/18/93 arrived. New battery installed. 0.5 0.5
06-23-93 1039 Speedometer is not functioning. Broken wire to the speed sensor repaired. 14.0 3.0
06-30-93 1866 Bus would not start. Start interlock switch is out of adjustment. (engine compartment) Interlock re-adjusted. 0.5 0.5
07-01-93 2044 Rivet missing top left side of rear door. Rivet replaced. 0.25 0.25
07-04-93 2669 Speedometer is not functioning. Broken wire to the speed sensor repaired. 1.0 0.25
07-07-93 3072 Wire broken at radiator sending unit is broken. Wire replaced. 0.25 0.25
07-08-93 3275 Speedometer is not functioning. Broken wire to the speed sensor repaired. 1.0 1.0
07-08-93 3275 Wheelchair lift is inoperative. Circuit breaker is tripped. Circuit breaker will not reset, new breaker ordered. 0.25 0.25
07-09-93 3472 A/C circuit breaker ordered 7/8/93 arrived. Circuit breaker installed, rear A/C unit operating. 0.5 0.5
07-13-93 4120 Wheelchair lift circuit breaker ordered 7/8/93 arrived. Circuit breaker installed. While testing lift operation, the lift quit functioning. Trouble shooting found 3 amp fuse blown due to short in ground sensor wiring. Short repaired, fuse replaced, lift operational. 3.0 3.0
07-15-93 4825 Wheelchair lift; three wires to the ground sensor are broken. Wires repaired. 0.5 0.5
07-18-93 5554 Speedometer is not functioning. Wires to speed sensor repaired. 0.5 0.5
07-20-93 5929 Speedometer is not functioning. Wires to speed sensor repaired. 13.0 0.5
07-21-93 5996 Speedometer is not functioning. New speed sensor ordered. 0.0 0.0
07-22-93 5996 Speedometer is not functioning New speed sensor installed. 24.0 0.5
07-28-93 7332 Front A/C unit not cooling. Trouble shooting; loose relay in the A/C electrical panel is loose. Relay tightened. 1.0 1.0
07-28-93 7332 Wiring/air line harness routed through the left rear is chaffing on the rear axle lateral bar. Harness wrapped with rubber and tied off away from the lateral bar. 0.25 0.25
08-09-93 8618 Wire broken to wheelchair lift coil. Wire repaired. 0.25 0.25
08-24-93 11250 Marker lights not functioning. Trouble-shooting; wires chaffed through, wires repaired. 2.0 2.0
07-28-93 7332 Flex pipe off of turbo is broken. Flex pipe and elbow replaced. 1.0 1.0
08-06-93 8618 All four radiator supports are worn. Radiator supports replaced. 1.5 1.5
08-09-93 8618 Both rear motor mounts are worn. Both rear motor mounts replaced. 1.5 1.5
08-09-93 8618 Engine compartment electrical panel mounting bracket is broken. Bracket welded/repaired. 1.0 1.0
08-18-93 10183 Right side radiator bracket has three broken bolts. Three bolts replaced in the radiator bracket. 1.0 1.0
06-22-93 962 Main fuel line ahead of the engine and rear of differential is loose. Fuel line tightened. 0.25 0.25
08-06-93 8618 Fuel sediment bowl mounting strap is broken. Strap replaced. 1.5 1.5
08-06-93 8618 Wire to alternator is chaffing on fuel line. Wire repaired and routed away from fuel line. 0.5 0.5
08-09-93 8618 Fuel line near transmission is leaking.. Fuel line tightened. 0.25 0.25
06-18-93 284 Wheelchair lift is inoperative. Trouble shooting found circuit breaker tripped and will not reset. New breaker ordered. 2.0 2.0
06-21-93 694 Rep. arrived with parts ordered on 6/18/93 for wheelchair lift. Rep. replaced curcuit breaker and control coils. Lift is now operative. 1.0 1.0
06-22-93 962 AM-FM radio is loose. Fastener tightened. 0.25 0.25
06-22-93 962 Wheelchair lift barrier down not functioning. Damaged wire to switch repaired. 0.25 0.25
08-09-93 8618 Mounting bracket for wheelchair lift hydraulic controls is broken. Bracket welded/repaired. 0.5 0.5
08-09-93 8618 Rear brace in handicap entrance stepwell is broken. Brace welded/repaired. 1.0 1.0
08-13-93 9461 Wheelchair lift hydraulic control compartment tray is loose. Fasteners tightened. 0.25 0.25
08-24-93 11250 Wheelchair lift hydraulic control compartment; welds are broken. Manufacturer recommends no repair due to completion of durability testing. 0.0 0.0
08-24-93 11250 Welds are broken on stepwell mounting brackets in handicap entrance. Manufacturer recommends no repair due to completion of durability testing. 0.0 0.0
07-13-93 4120 Rear lateral bar mounting bracket at the axle location is loose. Fasteners re-torqued. 0.5 0.5
07-15-93 4825 Bolts loose on the radius rod mounting tower. Bolts re-torqued. 0.25 0.25
07-26-93 6867 Right side ride height is too low. Ride height adjusted. 0.5 0.5
08-02-93 8179 Front right rear air bag, upper support has a broken bolt. 1/2" x 2" bolt replaced and torqued. 0.5 0.5
08-24-93 11250 Left upper air bag mounting plate is cracked approximately 1/8" and right rear mounting plate is cracked approximately 2". Manufacturer recommends no repair due to completion of durability testing. 0.0 0.0