D40 LF

NEW FLYER Pdf Download PDF Report

Unscheduled Maintenance

Date Test Miles Service Activity Downtime Hours
10-10-95 8713 The left side folding seat is broken at the pivot. Seat removed. 0.5 0.5
08-18-95 2477 The sun visor will not lock in place. Locking device tightened. 0.5 0.5
08-23-95 3207 The left rear compartment door; the strut mount has fallen off. Strut mount replaced with reivets. 0.5 0.5
10-10-95 8713 Three screws are missing from the side console. Screws replaced. 0.25 0.25
10-23-95 10270 Broken rivet in trim above the driver's window. Rivet replaced. 0.25 0.25
10-23-95 10270 The windshield gasket bead is working out at the upper right. Bead replaced. 0.25 0.25
10-23-95 10270 Headlights and instrument panel light are going out intermittently. Trouble shooting, loose D.R.L. module tightened. 1.0 1.0
11-06-95 12693 Two rivets are broken at the base of the windshield center post. Rivets replaced. 0.25 0.25
08-23-95 3207 The dash mounted starter button has fallen out of the dash. Button reinstalled. 0.5 0.5
09-15-95 5666 Trouble shooting for over heating condition. Cooling fans are inoperative. Inspect coolant level, hydraulic reservoir. Repaired broken wire on the coolant temperature sending u nit. 4.0 2.0
09-27-95 7244 Check engine light is on. Trouble shooting with Pro-Link; found active code "throttle input low volteage", TPS counts-15, and TPS pct.-fail. While trouble shooting TPS system, the check engine light went out and codes were gone. 1.0 1.0
09-28-95 7393 The speedometer lamp is burned out. Lamp replaced. 0.5 0.5
11-06-95 12693 The center brake light is out. Center brake lamp replaced. 0.25 0.25
11-17-95 12901 Bus is disabled on the durability track. Trouble shooting found many electrical circuits not operating. Found PLC processor not functioning properly. Contacted manufacturer for further instructions. Fault system cleared in the PLC processor. 136.0 8.0
08-18-95 2477 Coolant surge tank; the left bracket is broken. Bracket welded/repaired. 1.0 1.0
08-25-95 3620 The inner most bracket on the coolant surge tank is broken. Bracket welded/repaired and manufacturer-supplied gusset added. 1.5 1.5
10-04-95 7834 Inspect for fuel leak in the engine compartment. Replaced two leaking fuel lines. One from the rear cylinder to the filter and one from the DDEC block to the pump. 1.0 1.0
10-10-95 8713 The engine belt safety cage is broken in several places. Cage welded/repaired. 1.0 1.0
10-23-95 10270 The left motor mount is loose. Mount retorqued. 0.25 0.25
11-22-95 13965 The right side motor mount is broken. Replaced the right side motor mount. 1.0 1.0
08-11-95 1248 The wheelchair lift is running rough. Wheelchair lift hydraulic valve cleaned. 2.0 2.0
08-18-95 2477 The wheelchair lift is still running rough. Manufacturer-supplied a new orfice disc for the hydraulic valve. Disc installed. 0.5 0.5
09-13-95 5455 The left and right lower rear radius rod bushings are worn. Bushings replaced. 4.0 2.5
09-22-95 6659 The front leveling valve mounting bracket has cracked through the bolt hole. Mounting bracket welded/repaired. 5.0 3.0
09-28-95 7393 The left rear, rear shock is leaking oil. Replaced the left rear, rear shock. 0.5 0.5
10-02-95 7718 Both forward shocks on the rear axle and the left rear shock on the rear axle are leaking oil. All three shocks replaced. 1.5 1.5
10-17-95 9314 Broken right front radius rod. Both front radius rods removed for replacement with new design radius rods. New mounting holes drilled for installation of new design rods. New radius rods installed. 24.0 14.0
10-23-95 11727 The right rear lower radius rod bushing is worn, (rear suspension end). Right rear lower radius rod replaced. 1.0 1.0
11-06-95 12693 The snap ring and spacer is out and the bushing is worn on the right rear lower radius rod. Right rear lower radius rod replaced. 1.0 1.0
11-24-95 14154 The rear bushing on both upper rear radius rods are worn. Replaced both radius rods. 1.5 1.5
11-30-95 14804 The inside mounting bolt is broken on the left lower rear radius rod (rod-to-body) and the outside bolt is loose. Loose bolt retorqued and the broken bolt replaced. 6.0 2.5
10-23-95 11727 Both front tires are worn. Both front tires replaced. 1.0 1.0