TL-960

THOMAS BUILT Pdf Download PDF Report

Unscheduled Maintenance

Date Test Miles Service Activity Downtime Hours
09-26-96 783 The air conditioning alternator bearings are worn. Air conditioning alternator replaced. 2.0 2.0
10-09-96 2245 Two bolts are broken in the battery tray. Bolts replaced. 0.25 0.25
10-24-96 4819 The left rear, lower body panel (below the A/C compartment door) is cracked approximately 3". 2 1/2" X 1 3/4" piece of L-bracket installed to the cracked area. 0.5 0.5
10-24-96 4819 Striker mounting screw for the forward section of the rear door has backed out causing interference with the door. Screw retorqued. 0.25 0.25
11-01-96 5734 The support brace for the electrical box in the engine compartment is missing a bolt. Bolt replaced. 0.5 0.5
11-01-96 5734 Both left and right rear lower body panels are loose. Fabricate and install missing body brackets. 0.5 0.5
11-06-96 6273 The rear body panels are missing several rivets. Rivets replaced. 0.5 0.5
11-06-96 6723 Battery tray is not secure. 12" X 1" steel strap welded to secure battery tray. 0.5 0.5
11-06-96 6273 The right rear mesh panel is missing 5 fasteners. Fasteners replaced. 0.25 0.25
11-19-96 8264 The right rear lower body panel is broken. Installed a 4" X 12" aluminum plate from the inside to secure body panel. 0.5 0.5
11-19-96 8264 The welds are broken on the battery tray hold down block. 2" X 27" steel strap welded to the bottom of the battery tray. 1.0 1.0
11-19-96 8264 Frame bolts are missing from the following seats; the four seats across the rear, both left and both right rear seats, 2nd seat from the front (left side), two seats forward and the two seats behind the rear door. All frame seat bolts replaced. 1.5 1.5
09-23-96 605 Engine will not crank. Trouble shooting found loose positive battery cable, cable tightened. 2.0 2.0
09-26-96 783 Both 12 volt batteries have bad cells. Both 12 volt batteries replaced and battery tray secured. 2.0 2.0
10-16-96 3192 Both 12 volt batteries have bad cells. Both 12 volt batteries replaced and battery tray secured. 1.0 1.0
10-31-96 5655 The rear heating unit will not function. Rear thermostat adjusted to 70 degrees, replaced a broken power wire to the front circulating pump switch. 2.0 2.0
11-06-96 6273 The clearance lights are inoperative. Located and repaired shorted wire located at the left side, center clearance light. 1.5 1.5
09-30-96 1141 As per manufacturers request. Idler pulley installed for the alternator and water pump drive belt. Installted a bracket on the alternator for belt adjustment. 2.0 2.0
10-18-96 3590 All upper radiator support mounts are worn. Replaced all upper radiator support mounts. 1.0 1.0
10-18-96 3590 Both rear engine mounts are worn. Both rear engine mounts replaced. 0.5 0.5
10-24-96 4819 The lower radiator mounts are worn. Replaced lower radiator mounts. 1.0 1.0
11-19-96 8264 Both rear engine mounts are worn. Replaced both rear engine mounts. 1.0 1.0
11-19-96 8264 The lower left radiator bushing is worn. Bushing replaced. 0.5 0.5
10-24-96 4819 The front lateral bar mount gusset (axle side) has a 3" crack. Crack welded/repaired. 1.0 1.0
11-01-96 5734 The right front upper shock stud is broken. Shock stud welded/repaired. 1.0 1.0
11-06-96 6273 The right rear lower shock stud is broken. Shock stud welded/repaired. 2.0 2.0
11-11-96 6928 The bracket for the air dryer is broken. Bracket welded/repaired. 0.5 0.5
10-24-96 4819 The "Rollstop Up" operation for the handicap device will not function. Rollstop Up switch adjusted. 0.5 0.5
10-09-96 2245 All shock bushings are worn. Replaced all shock bushings. 1.0 1.0
10-14-96 2837 Broken bolt on the Ridewell right front suspension tower. Broken bolt replaced and torqued. 0.5 0.5
10-18-96 3590 All shock bushings are worn. Replaced all shock bushings 1.0 1.0
11-11-96 6928 Bolt missing on the Ridewell right front suspension tower. Bolt replaced and torqued. 0.5 0.5
11-19-96 8264 The left rear shock is leaking oil. Left rear shock replaced. 0.5 0.5