SENTRY
GOSHEN COACH
|
Date | Test Miles | Service | Activity | Downtime | Hours |
---|---|---|---|---|---|
07-09-97 | 4699 | The battery compartment door will not stay closed. | Disassembled latches and cleaned, reassembled and adjusted. | 0.5 | 0.5 |
07-09-97 | 4699 | The left latch on the engine compartment door has fallen apart. | Latch reassembled. | 0.5 | 0.5 |
07-10-97 | 4948 | The dash and steering column are loose. | Replaced missing bolts. | 2.0 | 2.0 |
06-19-97 | 2092 | The clearance and instrument panel lights are inoperative. | 20 amp blown fuse replaced. Located and repaired short in the clearance light wire (shorted to the frame near the lower left side corner of the radiator. | 1.0 | 1.0 |
05-20-97 | 175 | Engine cranks but will not start. | Checked fuses, wiring harnesses and connections, all o.k. Found one loose cannon plug. Plug tightened. Engine will idle but has no power. Shuts down during stall test and engine diagnostic light comes on. Manufacturer notified. Cummins rep. will come in. | 2.0 | 2.0 |
05-20-97 | 175 | Found a fuel leak at the high pressure regulator. | Tightened loose bolts on high pressure regulator cover. | 0.25 | 0.25 |
05-28-97 | 176 | Cummins rep. arrive for service. | Cummins rep. trouble shooting comments: hooked up computer, no current codes from ECM. Erased old fault codes from ECM. Ran unit on monitor, all seems ok. 94% throttle plate movement. RPM's register. Regulated gas pressure from high pressure regulator is 94 psi., low pressure regulator is 48 psi. Fuel pressure readings do not change as engine runs rough and shuts down. Left front ire had to be removed due to limited access to the fuel inlet fitting at the secondary regulator. Checked primary fuel pressure. Ran unit, as the engine warms up it will idle sometimes;. | 216.0 | 16.0 |
06-17-97 | 1679 | Both rubber muffler hangers are broken and a bolt is missing on the tailpipe hanger over the rear axle. | Replaced both rubber hangers and bolt. | 1.0 | 1.0 |
06-17-97 | 1679 | Check for engine oil leak. | Replaced damaged #1 valve cover gasket. | 1.0 | 1.0 |
06-17-97 | 1679 | The windshield washer reservoir is loose. | Replaced missing sheet metal screws. | 0.5 | 0.5 |
06-20-97 | 2256 | Drivers reported a noise under the bus when braking. | Found the drive shaft yolk behind the carrier bearing hitting the safety strap when stopping quick. Repaired damaged safety strap. | 0.5 | 0.5 |
07-11-97 | 5186 | The engine is shutting down on the test track. | Replaced fuel filter. | 1.0 | 1.0 |
06-30-97 | 3382 | The left side frame-to-bracket botls are broken on the front stabilizer link. | New nets and bolts installed. | 1.5 | 1.5 |
06-24-97 | 2722 | The front spring eye bolt on the left front spring is broken. | Replaced bolt. | 0.5 | 0.5 |
07-09-97 | 4699 | The bushings are worn on the right front shock. | Bushings replaced. | 1.0 | 1.0 |
General
Check-In
Back to Bus List
- Summary
- Weight
- Clearances
- Body Details
- Engine
- Transmission
- Suspension
- Wheels & Tires
- Brakes
- HVAC
- Steering
- Capacities
- Misc.
- Components
- Spare Parts
- Integrity Summary
- Shakedown
- Distortion Summary
- Distortion Test
- Static Towing Summary
- Static Towing Test
- Dynamic Towing Summary
- Dynamic Towing Test
- Jacking Summary
- Jacking Test
- Hoisting Summary
- Hoisting Test
- Durability Summary
- Durability Mileage
- Unscheduled Maintenance
- Interior Summary
- Stationary Test
- Acceleration Test
- Vibration Test
- Exterior Summary
- Constant Acceleration
- Standstill Acceleration
- Stationary
Back to Bus List