DE40LF

NEW FLYER Pdf Download PDF Report

Unscheduled Maintenance

Date Test Miles Service Activity Downtime Hours
03-25-09 560 Numerous window screws are backing out. Tightenend window screws. 0.25 0.5
03-25-09 560 The right side wiper arm is broken. Replaced right side wiper arm. 0.25 0.5
03-23-09 145 Bus has a "Drive Fault" upon accelerations. BAE rep adjusted the current to the drive motor. 14.0 1.0
03-26-09 774 Numberous window screws continue to back out. Redrilled screw holdes and installed new screws. 1.0 2.0
04-01-09 1687 The left front tire is leaking air. Replaced valve stem and tire. 6.0 2.0
04-02-09 1860 The left front air bag ruptured. Replaced left front air bag. 3.0 2.0
04-06-09 1975 The front suspension is low. The right front air bag has a hole. Replaced right front air bag. 26.0 2.0
04-07-09 2204 Manufacturer requests the front air bag be replaced with new air bags equipped with internal bump stops. Replaced front air bags with new internal bump stop air bags. 2.0 4.0
04-15-09 3783 Two high voltage cables are chaffing near the transmission. BAE rep installed separator and covered chaffed area. 3.0 1.0
04-16-09 3910 The windshield wipers will not shut off. Replaced wiper switch 0.5 0.5
04-16-09 3910 The left side, outside rear-view mirror is loose at the body mount. Installed new fasteners and secured mirror. 0.5 1.0
04-16-09 3910 The lower, rear axle radius rods bushings are worn. Replaced lower, rear axle radius rod bushings. 1.0 2.0
04-16-09 3910 The right front air bag is worn. Replaced right front air bag. 0.5 1.0
04-16-09 3910 The lower mounting plates for both front air bags are contacting the wheel wells. Removed both plates and 1/4" ground from the contact area as per manufacturer's request. 1.0 2.0
04-16-19 3910 Numerous window fasteners are coming loose. Installed thirty (30) pop rivets to six window frames. Three windows on the right and three windows on the left. 2.0 4.0
04-20-09 4293 The fan control switch is out of position. Replaced defective fan switch. 0.5 1.0
04-21-09 4483 The bus ride height is low in the right side. Manufacturer's rep replaced failed front leveling valve. 1.0 1.0
04-23-09 4929 The bus is shutting down intermittently. "Check System" and "System Shutdown" lights are on. Manufacturer's rep removed 36 fault codes. 2.0 2.0
04-30-09 6514 The right front air bag is worn from chaffing on the frame. Replaced right front air bag. 0.5 1.0
04-30-09 6514 The pivot point is worn on the rear leveling valve. Manufacturer's rep replaced rear leveling valve. 0.5 0.5
04-30-09 6514 The drive motor power cable P-clip is broken. Replaced manufacturer's rep p-clip. 0.25 0.25
04-30-09 6514 The driver heater motor came apart. Manufacturer's rep reassembled heater motor. 1.0 1.0
04-30-09 6514 After test drive, bus was shut off and would not restart. System troubleshooting by BAE technician. No problem found. Bus is now running. 16.0 1.0
05-06-09 7415 The left front air bag is leaking at the top plate. Replaced left front air bag. 5.0 1.0
05-08-09 7744 The steering column is loose. Installed one 1/4" x 2 3/4" bolt at the base of the column through the floor. Replaced all 4 locknuts at the column clamps. 5.0 4.0
05-07-09 7556 The bus is shutting off intermittently while running on the durability track. BAE rep troubleshooting found a high voltage DC ground fault condition that was preventing the bus from starting. Rep was able to temporarily "Mask" the fault to allow the bus to start. Rep replaced the SW to provide a "permanent mask" of the fault. Further investigation of the DC ground fault by BAE reps is pending. 12.0 12.0
8795 The 12/24 volt system is dropping in voltage while under load. Installed new batteries. 5.0 0.5
8795 The 12/24 volt system is dropping in voltage while under load. Installed new batteries. 5.0 0.5
8795 The 12/24 volt system is dropping in voltage while under load. Installed new batteries. 5.0 0.5